Readylift Ford F350 Super Duty: 2005-2007, 4WD, Track Bar Br Manuel d'utilisateur télécharger pdf

ReadyLift® (Part# 67-2535 & 67-2538) Installation Instructions

2005-UP Ford F-250/F-350 Super Duty 4WD

ReadyLift Suspension, Inc.

Toll Free (800) 549-4620

SAFETY WARNING:ReadyLift Suspension Inc. recommends this system be installed by a professional techni-

cian. In addition to these instructions, professional knowledge of disassembly/ reassembly procedures and

post installation checks must be known.

PRODUCT SAFETY WARNING:Modifying your vehicle ride height may result in the vehicle handling differ-

ently than a factory equipped vehicle. Extreme care must be used to prevent loss of control or vehicle rollover.

Failure to drive your modified vehicle safely may result in serious injury or death. ReadyLift Suspension Inc.

does not recommend the combined use of suspension lifts, body lifts, or other lifting devices. You should

never operate your modified vehicle under the influence of alcohol or drugs. Always drive your modified vehicle

at reduced speeds to ensure your ability to control your vehicle under all driving conditions. Always wear your

seat belt.

Pre-Installation Notes

1. Special literature required: OE Service Manual for model/year of vehicle. Refer to manual for proper disas-

sembly/reassembly procedures of OE and related components.

2. Adhere to recommendations when replacement fasteners, retainers and keepers are called out in the OE

manual.

3. Larger rim and tire combinations may increase leverage on suspension, steering, and related components.

When selecting combinations larger than OE, consider the additional stress you could be inducing on the OE

and related components.

4. Post suspension system vehicles may experience drive line vibrations. Angles may require tuning, slider on

shaft may require replacement, shafts may need to be lengthened or trued, and U-joints may need to be re-

placed.

5. Secure and properly block vehicle prior to installation of ReadyLift Suspension Inc. components. Always

wear safety glasses when using power tools.

6. If installation is to be performed without a hoist, ReadyLift Suspension Inc. recommends rear alterations

first.

7. Due to payload options and initial ride height variances, the amount of lift is a base figure. Final ride height

dimensions may vary in accordance to original vehicle attitude. Always measure the attitude prior to beginning

installation.

POST-INSTALATION WARNINGS

1. Check all fasteners for proper torque. Check to ensure for adequate clearance between all rotating, mobile,

fixed, and heated members. Verify clearance between exhaust and brake lines, fuel lines, fuel tank, floor

boards and wiring harness. Check steering gear for clearance. Test and inspect brake system.

2. Perform steering sweep to ensure front brake hoses have adequate slack and do not contact any rotating,

mobile or heated members. Inspect rear brake hoses at full extension for adequate slack. Failure to perform

hose check/ replacement may result in component failure. Longer replacement hoses, if needed can be pur-

chased from a local parts supplier.

3. Headlight adjustment is highly recommended.

4. Re-torque all fasteners after 500 miles. Always inspect fasteners and components during routine servicing.

1 2 3

Résumé du contenu

Page 1 - ReadyLift Suspension, Inc

ReadyLift® (Part# 67-2535 & 67-2538) Installation Instructions 2005-UP Ford F-250/F-350 Super Duty 4WD ReadyLift Suspension, Inc. Toll Free (800)

Page 2 - Toll Free (800) 549-4620

ReadyLift® (Part# 67-2535 & 67-2538) Installation Instructions 2005-UP Ford F-250/F-350 Super Duty 4WD ReadyLift Suspension, Inc. Toll Free (800)

Page 3

ReadyLift® (Part# 67-2535 & 67-2538) Installation Instructions 2005-UP Ford F-250/F-350 Super Duty 4WD ReadyLift Suspension, Inc. Toll Free (800)

Commentaires sur ces manuels

Pas de commentaire

Readylift Ford F350 Super Duty: 2005-2007, 4WD, Track Bar Br Manuel d'utilisateur

Naviguer en ligne ou télécharger Manuel d'utilisateur pour Outils Readylift Ford F350 Super Duty: 2005-2007, 4WD, Track Bar Br. ReadyLIFT Ford F350 Super Duty: 2005-2007, 4WD, Track Bar Bracket User Manual Manuel d'utilisatio

Résumé du contenu

Commentaires sur ces manuels

Produits connexes et manuels pour Outils Readylift Ford F350 Super Duty: 2005-2007, 4WD, Track Bar Br